Free in-home measure and quote - PGT, CGI and CWS impact lines compared on your actual openings, style by style
Sliding glass doors
Impact garage doorsPGTCGI
Before
After
Before
After
Before
AfterES Windows Roof Replacement & Installation in Stuart: What to Know First
We repair and install ES Windows skylights, roof glazing, and structural glass in Stuart homes, with most jobs finished in one or two visits depending on what the opening reveals. Replacement of a failed ES Windows roof unit typically runs $1,400 to $4,900 in the Stuart market, and the honest truth is that some failures are repairable for far less. If you own an ES Windows product that leaks, fogs, or has lost its seal, call (754) 324-4646 and we’ll tell you what you’re actually looking at before you spend a dollar.
This page is for Stuart homeowners who bought ES Windows glass because it was specified as premium, and now have water where it should not be. We’re an independent ES Windows service provider, not a factory rep, so we have no reason to defend the product instead of fixing it.
How ES Windows Products Fail - and How We Fix Them
- ES Windows skylight curb flashing separation. The ES Windows fixed skylight line relies on a factory curb-mount detail that, in Stuart’s salt air and afternoon downpours, separates where the aluminum cladding meets the curb after about 12 to 15 years. Water travels under the flashing and presents as a ceiling stain well away from the glass itself. We remove the unit, rebuild the curb, and reset the skylight with stainless hardware and a full-width membrane pan. This is the most common ES Windows roof failure we see in Stuart, and it is almost never the glass.
- ES Windows operable roof vent gear strips. On ES Windows motorized roof vents, the drive gear is nylon, and it strips clean when debris gets into the track after a hurricane season. The unit throws a fault or hums without moving. We can often replace the gear and drive assembly without pulling the entire vent, which saves most of a full replacement bill.
- ES Windows laminated roof panel edge delamination. In Stuart’s humidity, the laminated interlayer on certain ES Windows roof panels begins to cloud at the edges first, then spider inward. The manufacturer calls this cosmetic; anyone looking up through it calls it a failed window. Once delamination reaches the sightline, the correct repair is a new IGU. We’ll measure the rough opening, tell you plainly whether the panel can be reglazed in place or the whole frame needs to come out, and quote it both ways.
- ES Windows sun tunnel ring condensation. The flared ceiling ring on ES Windows sun tunnels can sweat in Stuart’s summer attic heat because the original seal between the tube and the roof deck is a foam gasket that compresses and hardens. Moisture beads on the ring, and the homeowner thinks the tube is leaking. We re-insulate the chase and reseal the roof penetration from above, which cures the condensation without replacing the tunnel.
- ES Windows structural ridge glazing seal failure. On ES Windows ridge and curb glass used in living rooms and sunrooms, the structural silicone that holds the glass in its channel has a realistic service life of about 20 years in the Treasure Coast sun. When it fails, the glass drops slightly in the frame, the weep system stops working, and water rides the gasket straight into the ceiling. We re-bed the glass, restore the weeps, and pressure-test the assembly before we call it done.
Our ES Windows Roof Replacement & Installation Process
Here’s how a ES Windows roof job runs when you call TruePane Windows & Doors.
- 1
We answer the phone. A live person takes your call at (754) 324-4646, asks what you’re seeing, and schedules a time that works. No form, no callback.
- 2
We inspect the roof and the opening. Our technician examines the ES Windows unit, the flashing, the curb or channel, the interior ceiling, and the attic chase if there is one. We measure the rough opening twice, because the first rule on every job is that if the opening is right, the rest is just doing the work.
- 3
We tell you the truth about the parts. If the failure is repairable with either OEM ES Windows components or a quality aftermarket equivalent, we quote both side by side on paper. You see exactly what you’re buying and what each option costs. We register every warranty layer in writing before we leave the driveway.
- 4
We do the replacement or repair. Roof work happens dry-in first: old unit out, opening prepped and waterproofed, new or repaired glass set and sealed, flashing and membrane installed so water from a Stuart afternoon storm sheds away from the opening, not toward it.
- 5
We test and clean up. We water-test roof penetrations, cycle any operable gear, confirm the weeps flow, and wipe down every surface we touched. The roof looks better than we found it or we’re not done.
- 6
We stand behind it in writing. Every ES Windows roof job gets our Done Right Promise. If it’s not done right, we make it right. No paperwork fight, no fine print.
What ES Windows Roof Replacement & Installation Costs in Stuart
Here are real numbers for the ES Windows roof work we do in Stuart. These are installed prices, not parts-only bait.
- Fixed skylight reflashing and curb rebuild: $1,200 - $2,300
- Motorized roof vent gear and drive replacement: $480 - $950
- Sun tunnel ring reseal and attic chase re-insulation: $350 - $700
- Seal failure repair on an operable ES Windows roof vent: $600 - $1,200
- Full ES Windows fixed skylight replacement with new curb: $2,100 - $4,900
- Ridge glazing re-bed and weep restoration: $900 - $2,200 depending on linear feet
What moves the price is access, the condition of the roof deck under the unit, and whether the surrounding roofing material needs tied in after we finish. We quote a fixed price before we start, and the bill does not grow after the work begins. Call (754) 324-4646 for a free estimate on your ES Windows roof unit.
Why Stuart Homeowners Call TruePane Windows & Doors for ES Windows Work
We have been serving Martin County since 2008, and the founding rule has not changed: if the pane is not true, the job is not done. That is why a Stuart homeowner with a ES Windows roof unit who is tired of chasing leaks calls us instead of rolling the dice on another generalist.
Our technicians know ES Windows construction, but we also carry working knowledge of PGT, CGI, CWS, and ECO Window Systems. That matters because half the time a “ES Windows problem” on a Stuart roof is actually a flashing issue, a deck issue, or a previous installer’s shortcut. We diagnose what is actually in front of us. We hire local, train our people, and answer the phone 24 hours a day. And when we say the job is done, it’s done, in writing, for 90 days. That’s The Keystone Standard, and we put it on every invoice.
FAQs
Most ES Windows warranties on roof units cover glass and seal integrity for a stated period, but they usually exclude flashing, curb, and installation-related leaks. We review your paperwork on the first visit and tell you exactly what is covered and what is not, then register both warranty layers in writing if any work qualifies.
In most cases, yes. We match the glass tint, thickness, and low-E coating to your remaining ES Windows units, and we can source OEM or equivalent IGUs. You will see the specs on the quote before we order anything.
Repair is usually cheaper when the frame, curb, and flashing are sound and only the glass or a single component has failed. Replacement makes sense when the frame is corroded, the curb is rotting, or the unit is old enough that another failure is guaranteed. We will quote both numbers and let you decide.
We answer live 24/7, and for a leaking roof unit we will schedule an inspection as fast as our Stuart route allows, typically within a day or two. If water is coming through the ceiling, call (754) 324-4646 and we will talk you through what to do until we get there.
When the scope of work requires a permit, we pull it, and we schedule the inspections. Roof penetrations and structural glazing in Martin County are not the place for a handshake and a wink. We do it to code and we pass.
If you own an ES Windows roof unit in Stuart and something is wrong, call (754) 324-4646 for a free estimate. We will tell you what you have, what it costs to fix, and whether it is worth fixing. No pressure, no surprise line items, just a square deal.
Written by Dale Kessler, Owner, TruePane Windows & Doors at TruePane Windows & Doors, serving Stuart and nearby areas.
Six Reasons Homeowners Choose TruePane Windows & Doors
Impact systems engineered to design pressures up to +/-100, matched to your wind zone - your openings hold when the storm arrives.
Low-E insulated impact glass from our manufacturer lines commonly cuts monthly cooling bills 20-30%.
Laminated impact glass shuts out up to 40% of outside noise - traffic, neighbors, weather.
Monitoring services run $30-90 a month. Laminated impact glass resists forced entry around the clock, with no subscription.
Florida homeowners average around 25% savings on the windstorm portion of their policy after protecting every opening - some homes qualify for more.
A full impact package upgrades curb appeal, buyer confidence and appraised value in one project.